Intel's spending on R&D climbed to 20% of sales in 2012; Samsung's held steady at 8%.
February 05, 2013 -- Spending on research and development by semiconductor companies grew 7% in 2012 to a record-high $53.0 billion, even though the semiconductor market declined 1% to $317.6 billion, according to the 2013 edition of IC Insights’ McClean Report. The increase lifted R&D spending by chip companies to 16.7% of total semiconductor sales in 2012, the highest level since the peak of 17.5% was reached in both 2008 and 2009.
For more than three decades, R&D spending as a percentage of total semiconductor sales has trended higher due to increasing costs associated with developing complex IC designs and creating next-generation process technologies to manufacture these circuits. In the late 1970s and early 1980s, R&D spending as a percent of semiconductor sales by chip companies was typically 7-8%. R&D-to-sales ratios grew to 10-12% of revenues by the early 1990s and then jumped to over 15% during the last decade, reaching a record 17.5% in 2008.
However, as shown in Figure 1, not all companies have seen a growing portion of sales consumed by R&D. For example, Samsung’s R&D-to-sales ratio fell from a peak of 25% in 2001 to 8% in 2010 and has remained there since. Samsung’s semiconductor business is more capital-intensive than it is R&D-intensive because of the commodity nature of the DRAM and flash memory business in which it mainly participates. As a result, since 2001, Samsung’s semiconductor sales have grown an average of 16% per year, while its R&D spending has increased at about one-third the rate (5%) and it’s capital expenditures have grown by an average of 19% annually. The main focus of Samsung’s investments is in adding new fab capacity for large-diameter wafers (currently 300mm but heading toward 450mm later this decade).
Intel’s business is also capital-intensive. Its spending on new fabs and equipment in each of the past two years was about $11 billion, which was only about $1 billion shy of what Samsung spent in each of those years. Intel’s advanced microprocessors and other incredibly complex logic devices have very short life cycles. Spending large amounts of money on research and development is part of its business model. Intel’s $10.1 billion in semiconductor R&D spending in 2012 was more than 7x the amount spent by second-place Qualcomm! In fact, Intel spent more than one-third of the combined $28.7B spent by the top-10 R&D spenders in 2012, according to the 2013 McClean Report.
Figure 1 also shows how much the industry’s largest pure-play foundry, TSMC, has been spending on R&D as a percent of sales over the past decade-and-a-half. As the process technology needed for each new generation of ICs has become increasingly difficult to develop, fabless companies and the growing number of fab-lite companies have come to rely on TSMC not only for fabricating their wafers, but also for helping to bring their IC designs into existence. As a result, TSMC’s R&D spending-to-sales ratio has been gradually climbing over the past 6-8 years. TSMC’s spending ratio reached 8% in 2001, but that had a lot to do with the fact that its sales were hit hard by the industry recession that year. Aside from a small dip in 2009, TSMC’s spending on R&D has grown every year since 1998 and at an average annual rate of 25%! Over that same 1998-2012 timeperiod TSMC’s sales grew an average rate of 19% per year.
Report Details: The 2013 McClean Report
A thorough analysis of semiconductor industry research and development spending trends is just part of the information included in the 2013 edition of IC Insights’ flagship study, The McClean Report—A Complete Analysis and Forecast of the Integrated Circuit Industry. The highly regarded annual report features more than 400 tables and graphs in the main report alone. A subscription to The McClean Report includes free monthly updates from March through November (including a 250+ page Mid-Year Report), and free access to subscriber-only webinars throughout the year. A single-user subscription to the 2013 edition of The McClean Report is priced at $3,390 and includes an Internet access password. A multi-user worldwide corporate license is available for $6,390.